Résumé
Intense spreading of livestock wastes are recognized to be detrimental to the environment due to their content of organic matter and mineral fraction. Then, it would appear to be necessary to promote greens treatments processes. In fact, anaerobic digestion allows the production of biogas (extremely useful source of renewable energy), whilst digestate should be a highly valuable biofertilizer This work enters in this approach by proposing to complete anaerobic digestion steps by the use of perm-selective membrane separation process. The first step is a clarification step by ultrafiltration, following by a soluble mineral concentration step by nanofiltration, low pressure and/or high pressure reverse osmosis (LPRO, HPRO). The tests were performed in a laboratory-scale pilot unit using real digestates. For clarification step, a cross-flow mode separation is obligate in view of suspended solid concentrations and viscosity which appeared as a determining factor for the choice of operative protocol. In any case, the ultra-filtration operation allows a high organic retention rate (of 80 to 90%). Conversely, soluble mineral retention remained at negligible as expected. The cut-off of ultrafiltration membrane is not a determining factor for this retention. Despite the cross-flow mode separation filtration induces a compound accumulation on the membrane which decreases significantly the permeability of filtering media. This permeability drop appears greater when suspension presents a high COD concentration. This criterion appears as a limiting factor to achieve a high volumic concentration factor (VCF). Membrane surface to develop is then directly related to the membrane permeability which depends on the digestate origin and VCF. The operational cost is linked directly to the energy required to ensure cross-flow mode. The retention of soluble mineral compounds by HPRO exceeds 90% whatever the target ions or the origine of digestate are. However, for NF and LPRO steps, this rejection depends on the target ions or the origine of digestate. In any case, organic retention is important (more than 90%) which allows significant discoloration of permeate. The, the more the electronic conductivity (EC) is, the more permeability decreases of suspension is important, due to an osmotic pressure and soluble compound accumulation on the membrane that increases with EC. This conductivity depends on initial digestate and, of course, of the chosen VCF target, which appears as decisive parameter for unit dimensioning. On the efficient energy, energy linked to separation step chosen is dominant in the absence of cross-flow mode of retentate. This work has allowed to confirm the potential interest of membrane separation to (i) obtain a final effluent: named fresh or new water and (ii) and (ii) to allow the production of liquid fertilizers.